# Introduction ompressed Natural Gas (CNG) has become a better option as a clean burning fuel of an IC engine. In order to comply with the ever-stringent emission norms throughout the world and crunch in petroleum reserves, the modern day automobile industry is compelled to hunt for new and alternative means of fuel sources to keep the wheels spinning globally [1]. Paradoxical objectives of attaining simultaneous reduction in emissions along with high performance has provided with a few alternative. Natural gas produces practically no particulates since it contains few dissolved impurities (e.g. sulphur compounds). Moreover, natural gas can be used in compression ignition engines (dual fuel diesel-natural gas engines) since the auto-ignition temperature of the gaseous fuel is higher compared to the one of conventional liquid diesel fuel [3]. Dual fuel diesel-natural gas engines feature essentially a homogeneous natural gas-air mixture compressed rapidly below its auto-ignition conditions and ignited by the injection of an amount of liquid diesel fuel around top dead center position. Natural gas is fumigated into the intake air and premixed with it during the induction stroke. At constant engine speed, the fumigated gaseous fuel replaces an equal amount of the inducted combustion air (on a volume basis) since the total amount of the inducted mixture has to be kept constant. Furthermore, under fumigated dual fuel operating mode, the desired engine power output (i.e. brake mean effective pressure) is controlled by changing the amounts of the fuels used. Thus, at a given combination of engine speed and load, the change of the liquid fuel ''supplementary ratio" leads to a change of the inhaled combustion air, thus resulting to the alteration of the total relative air-fuel ratio [1][2][3].In internal combustion engines, exhaust gas recirculation (EGR) is a nitrogen oxide (NOx) emissions reduction technique used in petrol/gasoline and diesel engines. EGR works by re-circulating a portion of an engine's exhaust gas back to the engine cylinders [5]. In a gasoline engine, this inert exhaust displaces the amount of combustible matter in the cylinder. In a diesel engine, the exhaust gas replaces some of the excess oxygen in the pre-combustion mixture, Because NOx forms primarily when a mixture of nitrogen and oxygen is subjected to high temperature, the lower combustion chamber temperatures caused by EGR reduces the amount of NOx the combustion generates. Most modern engines now require exhaust gas recirculation to meet the emission standard [4,[6][7][8][9]. # Experimental Procedure Series of several experimental cycles have been conducted with varying CNG percentages and iterations were done with varying exhaust gas recirculation and the results were compared. The engine used in the present study is a Kirloskar AV-1, single cylinder direct injection, Water cooled diesel engine with the specifications given in Table N0 1. Diesel injected with a nozzle hole of size 0.15mm.the engine is coupled to a dynamometer. Engine exhaust emission is measured. Load was varied from 0.5 kilo watt to 3 kilo watts. The amount of exhaust gas sent to the inlet of the engine is varied. At each cycle, the engine was operated at varying load and the efficiency of the engine has been calculated simultaneously. The experiment is carried out by keeping the compression ratio constant i.e., 16.09:1. The exhaust gas analyzer used is MN-05 multi gas analyzer shown in Fig. 1. (4 gas version) is based on infrared spectroscopy technology with signal inputs from an electrochemical c cell. Non-dispersive infrared measurement techniques use for CO, CO2, and HC gases. Each individual gas absorbs infrared radiation absorbed can be used to calculate the concentration of sample gas. Analyzer uses an electrochemical cell to measure oxygen concentration. It consists of two electrodes separated by an electrically conducted liquid or cell. The cell is mounted behind a polytetrafluorethene membrane through which oxygen can diffuse. The Device therefore measures oxygen partial pressure. If a polarizing voltage is applied between the electrodes the resultant current is proportional to the oxygen partial pressure. The important properties of diesel fuel and natural gas are given in Table 1. Table 1 : Properties of Diesel Fuel and Natural Gas a Natural gas consists of various gas species; from which methane (CH4) is the main constituent. The equivalent chemical composition of natural gas may be expressed as C1.16H4.32 [10]. b At normal temperature and pressure. From the chart1 it can be seen that up to 40% CNG substitution would be observed an increase in brake thermal efficiency of 10% compared to that of pure diesel, but 50% substitution of CNG has shown 5% decrease in brake thermal efficiency when compared to that of pure diesel. # Engine Specifications Chart 2 : Bth Vs EGR% at various CNG proportions The chart 2 represents the relation between brake thermal efficiency and percentage of Exhaust gas recirculation. it shows that with an increase in exhaust gas recirculation proportion the brake thermal efficiency has increased till 10% of substitution but decreased with above 10% substitution . The relation between volumetric efficiency and exhaust gas recirculation is represented in chart 3. It has been observed that the volumetric efficiency decreases with an increased substitution of compressed natural gas (CNG) and with increased exhaust gas recirculation (EGR). # Global Journal of Researches in Engineering # Chart 4 : NOx Vs EGR% at various proportions The chart 4 represented the trends of NOx with the EGR substitution. it is observed that, with an increase in exhaust gas recirculation NOx emission havedecreased by 28% at all proportions of CNG substitution. Chart 8 : in-cylinder pressure Vs crank angle for pure diesel, 10%CNG and 10%EGR substitution Chart 8 shows the pressure inside cylinder at varying crank angles of the cycle for pure diesel, 10% CNG substitution and 10% exhaust gas recirculation at 10% CNG substitution. # Global Journal of Researches in Engineering # IV. # Conclusion From the above obtained results the following conclusions were drawn: a) Substitution of CNG up to 40% has shown increase on brake thermal efficiency of 20% compared to that of pure diesel, but 50% 1![Figure 1 : Multi gas analyzer experimental set up](image-2.png "Figure 1 :") 2![Figure 2 : Block diagram of experimental set up A. Parts AB-air box, mmeasurement of air by manometer,FW-fly wheel, ADM-alternator dynamometer, i-fuel injector, C-computer for P-? interface, V-valve for fuel control, EGA-exhaust gas analyzer, S-piezoelectric sensor for p-? interfacing, PB-panel board, EP-exhaust gas probe, FT-fuel tank.](image-3.png "Figure 2 :") ![Analysis of Diesel Engine using CNG under Dual Fuel Mode with Exhaust Gas Recirculation ume XIV Issue II Version I Chart 3 : Vol. Eff. Vs EGR% at various CNG proportions](image-4.png "") 2TYPE4-STROKE, SINGLE CYLINDER,COMPRESSION IGNITION ENGINE, WITHVARIABLE COMPRESSION RATIO.Kirloskar AV-1MAKERated power3.7 KWSpeed1500 RPMYear 2014Bore and stroke Compression ratio80mm×110mm 16.09:1, variable from 13.51 to 19.6932Fuel Chemical formula Density (kg/m 3 ) Low heating value (MJ/kg) Flammability limits (% vol.) Laminar flame speed (cm/s) 5 Diesel C 10.8 H 18.7 -a Natur al gas 43 0.695 b 830 49 0.6-5.5 5-15 34 Octane number N/A 120Cylinder capacity Dynamometer Orifice diameter Fuel Calorimeter Cooling Starting553cc Electrical-AC Alternator 20 mm Diesel Exhaust gas calorimeter Water cooled engine Hand cranking and auto start also providedCetane number52N/AAutoignition temperature220580( ) A Vol( 0 C) (AFR stoic , kg air/kg fuel) Stoichiometric air-fuel ratio14.316.82Global Journal of Researches in Engineering© 2014 Global Journals Inc. (US) 3Year 201433( ) A VolNO X B th Vol. Eff. UHC PPM EGROxides of nitrogen Brake thermal efficiency Volumetric Efficiency Unburnt hydro carbons Parts per million Exhaust Gas RecirculationGlobal Journal of Researches in EngineeringCACrank AngleC. Brake Thermal EfficiencyChart1 represents the trends of brake the rmalefficiency with the substitution of compressed naturalgas (CNG) with corresponds to Brake power© 2014 Global Journals Inc. (US) shown 11% decrease in cylinder pressure (bar) CA(Deg) in cylider pressure Vs crank angle for purediesel, 10%CNG and 10%EGR substitutoin in brakethermal efficiency when comparedb) to that of diesel. The normal injection timing hasshown higher volumetric efficiency. Any how thetrend of varying volumetric efficiency has stood verygeneral.substitution of CNG has © 2014 Global Journals Inc. (US) * Experimental investigation concerning the effect of natural gas percentage on performance and emissions of a DI dual fuel diesel engine RPapagiannakis DHountalas Applied Thermal Engineering 23 3 February 2003 * Effect of hot exhaust gas recirculation on the performance and emissions of an advanced injection low pilotignited natural gas engine YQi HSrinivasan K CYang Midkiff International Journal of Engine Research 8 June 1, 2007 * RGPapagiannakisa PNKotsiopoulosa TCZannisb EAYfantisb DTHountalasc CDYear 2014 * Theoretical study of the effects of engine parameters on performance and emissions of a pilot ignited natural gas diesel engine Rakopoulosc 21st International Conference Energy February 2010 35 on Efficiency, Cost, Optimization, Simulation and Environmental Impact of Energy Systems * Effect of EGR on Performance and Emission Characteristics of Natural Gas Fueled Diesel Engine SKMahla LMDas MK GBabu Jordan Journal of Mechanical and Industrial Engineering 1995-6665 Pages 523 -530 4 4 September 2010 * Effects of exhaust gas recirculation (EGR) on combustion and emissions during cold start of direct injection (DI) diesel engine HaiyongPeng YiCui LeiShi KangyaoDeng March 2008 33 * The Effect Of Exhaust Gas Recirculation (Egr) In Compression Ignition Engine PratibhuRoy BijanSinha1 AchinKumar Mandal Kumar Chowdhuri International Journal of Emerging Technology and Advanced Engineering 3 2013. Feb 2013 * NOX reduction from a heavy-duty diesel engine with direct injection of natural gas and cooled exhaust gas recirculation McTaggart-Cowan G WKBushe PGHill SRMunshi Proceedings of the Institution of Mechanical Engineers the Institution of Mechanical Engineers 2004 5 International Journal of Engine Research * Comparison of GHG emissions from diesel, biodiesel and natural gas refuse trucks of the city of Madrid JMLópez AGomez FAparicio FJSanchez Applied Energy 86 5 2009 * An examination of some measures for improving the performance of gas fuelled diesel engines at light load Karim 1991 SAE Paper No. 912366 * Combustion and emission characteristics of a natural gas-fueled diesel engine with EGR MMAbdelaal AHHegab Energy conversion and management 64 2012